TROUBLE SYMPTOM CHART


Trouble symptom
Inspection procedure No.
Reference page
PHEV-ECU power supply system malfunction
1

Auxiliary battery discharged
2

Drive battery discharged
3

Drive battery power consumption or the abnormalities in a residual quantity display
4

Inefficient electric power consumption
5

Acceleration is bad
6
Acceleration may be also restricted when the high-voltage battery charge level is low or the high-voltage components are protected against heat. This is not a malfunction.
Charge is not completed (It stops on the way)
7

Quick charging is impossible, or the external power supply equipment (MiEV power BOX) cannot be used
8

Charging does not start, or the charging indicator is not illuminated when the charger is connected to domestic power supply
9

Charging time is longer than usual, or charging does not stop
10

Domestic circuit breaker interrupts the power supply
11

Abnormal noise (whistling or groaning noise)
12

Electric Shock
13

Connect the charging cable, the charging indicator does not flash (electric motor switch is set to ON)
14

EV system over heat (Water cooling system)
15

EV system over heat (Oil cooling system)
16

Over heat (Radiator fan and condenser fan do not operate)
17
Refer to GROUP 14A - Radiator fan and condenser fan do not operate <4B1-PHEV> .
Modes cannot be switched by using the battery charge switch
18

Modes cannot be switched by using the battery save switch
19

Modes cannot be switched by using the 4WD LOCK switch
20

Modes cannot be switched by using the ECO mode switch
21

Energy regeneration ratio cannot be changed by using the paddle shift switch
22

Brake warning lamp does not put out the light
23

Backup lamp does not light up normally
24

It is usually a poor normal charge connector signal
25